Walker WV Heating, AC Repair & Plumber

Cleaned and checked operation of equipment. All checks were good. Cleaned burners, blower compartment and outside of system. Recommend surge protector for equipment.

Performed Platinum Comfort Club Membership Tune-Up on Cooling System. Performed maintenance on 2019 Heil a/c and older Coleman modular home furnace w/ (2) 16x20x1 filters. Previous tech found a way to get a filter in blower section of door, however clear that it had been previous unfiltered, expected but removed decent build on motor of blower, wheel didn’t seem excessive though. No data tag remaining on inside run cap, believe it to be a 10mfd by readings and if so is in range. Outdoor unit is in great shape, operating smoothly. All other checks good at this time.

Installation of new heating and cooling system

Service Call Platinum Client Customer showed pictures of lines freezing on coil. Suspect system is low on refrigerant again. Called Lennox to find out system was out of warranty for not being registered. Quoted customer for replacing coil out of warranty. Recommend replacing system due to situation and past of the system. Customer wants to wait and see what he wants to do. If we come back to recharge we NEED it to be at least 70-75.

Performed Platinum Comfort Club Membership Tune-Up on Cooling System Replaced filter checked capacitor and amp draws. Fan motor is pulling very high amps and is making a grinding noise due to a failed bearing. Coil is rotted away from a neighbors dog peeing on coil. Refrigerant charge did check out to be ok but is very likely to develop a leak. Also found customers hot water tank connections to be corroded and leaking. Customer getting quotes on new AC and hot water tank.

Performed Platinum Comfort Club Membership Tune-Up on Cooling System Equipment was serviced and maintenance performed. Equipment is operating; however, due to current condition, age and wear an tear it will need replaced in a near future to guarantee proper operation during extreme hot and cold temperatures.

Performed Platinum Comfort Club Membership Tune-Up on Heating System Cleaned and checked operation of both furnaces. Changed 14-25-1 and 16-25-1 filters. Downstairs system is getting up there in age but at this time it is still operating safely. Upstairs: Exhaust amps 1.44 Blower amps 3.38 O2 9.5 Efficiency 95.8 Tstk 99 CO(0) 46ppm Temp rise 48

Surge Protector 120 Volt

Performed Platinum Comfort Club Membership Tune-Up on Heating System Cleaned and checked operation of equipment. Changed Aprilaire 213 filter. Recommend surge protector for equipment. Adjusted gas pressure down to proper level. All checks were good.

Performed maintenance on Bosch heat pump system w/ AA413 filter. Replaced filter. No natural gas at location, customer has propane as back up source. Surge protection present at unit. All checks good at this time.

water heater install

Service Call Platinum Client: customer had gas line work done recently, and furnace was not firing off. furnace was running fine when I got here. checked gas pressure to be sure, found it low at 1.9IWC. adjusted gas pressure to 3.3. possible that furnace needed to purge air in the gasline after broken pipe was repaired. found flame sensor also dirty. furnace is 25yo and has had a few parts replaced on it already. signed up for maintenance agreement and scheduled quote for replacement between 3-5pm today.

Removed and Replaced 50 Gallon Natural Gas Hot Water Tank with AO Smith ProLine 50 Gallon Natural Gas HWT, New Thermal Expansion Tank, Shut Off Valves, Gas Regulator and Vent.

Removed and Replaced 50 Gallon Natural Gas Hot Water Tank with AO Smith ProLine 50 Gallon Natural Gas HWT, New Thermal Expansion Tank, Shut Off Valves, Gas Regulator and Vent.

Performed Platinum Comfort Club Membership Tune-Up on Heating System Tested propane gas pressures. Inlet pressure was slightly higher than it should have been and adjusted outlet pressure as well. Low fire pressure was adjusted from 4.5 to 6.8. Filter was still in good condition. Turned humidifier on and verified it was working. REME LED still functioning properly as well. Recommend surge protector for equipment.

Performed Platinum Comfort Club Membership Tune-Up on Heating System - cleaned and checked operation of heat pump. Changed customer supplied Aprilaire 313 filter. Recommend surge protector for equipment.

Service Call Platinum Client Heat pump was found with low pressures 30psi/235psi under 40 degrees ambient temperature. It would go out on low pressure. Customer wanted to charge system despite the severity of issue. Once system was charged to 75psi/400psi temperature rise improved and its running properly. If issues continue, not a call back since customer is aware that this is temporary repair. If system is not replaced, repairs will be costly.

Performed Platinum Comfort Club Membership Tune-Up on Cooling System: Performed yearly checks on the air conditioner. All checks were good.