Parkersburg WV Heating, AC Repair & Plumber

14 yr old heil furnace. Replaced draft motor and control board.

Exhaust vent was not glued and completely detached from inducer motor.

Customer said furnace was not heating and flashing different fault codes. Board is fried from a possible power surge. Due to this cannot confirm good operation of other furnace components. Due to cost of the repair and age of equipment recommend replacement. Also recommend surge protectors on everything.

Replaced damaged draft motor on 30 yr old carrier furnace. Expressed to customer that we cannot guarantee proper operation of furnace given the age of furnace. Unit passed combustion analysis test. Customer does not have carbon monoxide detector in home, they said they will get one. Customer was interested in duct cleaning and plasma air cleaner. Duct cleaning is scheduled for the 18th of April, plasma air will be installed then as well.

Found failed inducer motor that will not operate. Quoted price for part replacement between $734-$1030. System is 14 years old and with cost of repair it might be a better option to replace system rather than just part. Attached photos of part number and model and serial number. Customer wants to replace motor at this time since they are selling the home.

Performed maintenance on equipment. Changed 20-25-1 filter and recommended surge protector for equipment. System was operating safely and properly at this time.

Performed maintenance on equipment. Changed 16-25-5(2) filters and replaced failing capacitor on blower motor. Verified working status of surge protection on furnaces but recommended installation of some on AC systems as well. Renewed maintenance agreement with customer. Please mail customer receipt.

Customer was not having issues with ac, they just wanted it cleaned. Hvac maintenance on mini split and split unit system. Units check good.

Performed heating and cooling check. Everything is operating within spec. Recommend an air purifier and a stem humidifier.

Blower motor has failed. Warranty motor and limit switch have been ordered and we will be back after parts are received. Customer has a 10&10 warranty.

Complete replacement of low efficiency furnace exhaust vent out and up the exterior wall. Sealed holes in walls. Tested furnace. Operating normally.

Performed maintenance on equipment. Changed 20-25-1 filter and recommend surge protection for system. Found no issues with the system.

Cooling maintenance check. Ac is 26 years old and in poor condition. Condenser coil is deteriorating. Contactor makes a loud buzzing noise. Capacitor is testing out of tolerance range. R22 refrigerant is low, maybe 2-3 lbs. Given the age and condition of unit repair is not recommended. Customer has requested to get an estimate for a new system. Estimate is scheduled today from 3-5pm. Customer also requested an appointment with the plumbers to flush his tankless hot water heater. Appointment for plumbers is scheduled tomorrow first appointment.

Changed filters, checked belts, capacitors, electrical, coils, blower wheels. Performed cooling check on rooftop systems.

Customer wants a Reme halo installed. They have some water issues with foundation in basement at time and are worried about mold. Discussed with them our iaq special we are running this month . They have decided to get duct work cleaned as well. They are on the schedule for April 17th for duct cleaning and reme install.

Vent has fallen off the wall completely and needs replaced.

Zone issue

Performed maintenance on equipment. Changed 16-25-1 filter and renewed comfort club membership with customer. Discussed plasma air air purifier and surge protection with customer.

Renewal

Renewal

Performed owed maintenance check on equipment. Changed AA413 filter and verified working status of surge protection and plasma air. All checks were good.

Performed heating check on all 3 systems. Changed filters. All equipment operating within spec. Recommend plasma air purifier to help filters.

Surge

Maintenance check on hvac system. Weather king furnace in basement is 21 years old and is in rough shape. Burner cabinet has rust under draft motor. Customer has had to replace igniter on furnace several times. Confirmed that furnace is putting out proper voltage to igniter. Capacitor for draft motor and blower are testing weak(3.2 and 12.7 mfd). Also pvc vent for exhaust has water leaking out of it near top of furnace. Ac is 20 yrs old and has a couple of issues as well. Dual cell capacitor is testing weak on compressor side and unit is also low on outdated r22 refrigerant, maybe a couple of pounds. Given to amount of repairs, age of system, and overall condition of split system I do not recommend repair. Mini split unit is running well but filters have not been cleaned on a regular basis. Filters very dirty and blower wheel is filthy. Unit has a smell to it when ac runs due to blower wheel. Recommended cleaning wheel and adding air cleaner to mini split. Customer also has a water le

Igniter is beginning to fail as it is only lighting up less than half way. Discussed repair option with customer and he elected to hold off on repair at this time. Also discussed special we are running for free furnace with AC purchase with customer. He was interested and will call in if wanting to schedule estimate.